web analytics
Bricks for outer arch - Forno Bravo Forum: The Wood-Fired Oven Community

Announcement

Collapse

I'm Peter Reinhart! Ask Me Anything! Monday, February 15, 2016 7:00-8:00 pm EST

To kick off our AMA feature, we have invited author, chef and master bread maker and host of Pizza Quest, Peter Reinhart, to be our first host! Peter will be in the Forum on Monday, February 15th, from 7:00 - 8:00 pm EST. If you are unable to be online during the live session, you can post your questions in the sticky post. Peter will answer those questions during the live session on February 15th. You can view Peter's answers to your questions as well as what happened during the live session in the session thread.

Ask Me Anything New Forum Feature

You will notice a new forum at the top of the main page called, "Ask Me Anything". This forum will be used for live one hour "Ask Me Anything" (AMA) sessions hosted by people who are knowledgeable in different areas pertaining to wood fired ovens. How it works:
- Each AMA will have a "sticky" thread where the community can post questions they would like answered during the live session. This will allow everyone to participate even if you can't be online for the live session. These questions will not be answered by the host until the live AMA; if you need an answer quickly, you should post it in the appropriate Forum area for the community to respond.
- Another thread will be posted for the live AMA. Registered users who are logged in during the live session can interact with the host by asking questions and receiving responses.
- The live thread will remain in the AMA forum to view after the session.

We hope you enjoy this new feature! Please let us know if there is a topic that you'd like to have as an AMA and we'll look for a host!

Forno Bravo
See more
See less

Bricks for outer arch

Collapse
X
  • Filter
  • Time
  • Show
Clear All
new posts

  • Bricks for outer arch

    I never thought I'd have so much trouble finding bricks for my decorative arch.... It seems like my only choice in clay bricks is between solid pavers that have a nice color on one surface only (and/or that don't come in the color I want), or clay house bricks (with holes in them ) that are colored by means of a sandy coating applied to the surface.

    Is it OK to use the latter? The trouble is, the colored coating comes off with a wire brush, revealing the ugly brown/orange clay underneath. Does anyone have experience using this type of brick on the outer arch, and will the color wear off as I slide pans across it?

    The other problem with these is that I wanted to use half-bricks, which means cutting them and exposing the clay on the cut surface (which will be showing on the underside of my arch).

    I've checked all the brick suppliers in town, but maybe I need to look elsewhere....

    Daren
    Picasa web album
    Oven-building thread

  • #2
    Re: Bricks for outer arch

    Daren. I used the house bricks you refer to, with holes. I don't know about your arch, but mine will only be seen from the front, and the underside. The top will stick out only a few cm from the facing stone veneer.

    Most bricks have at least 2 good sides. The front that is intended to face out, and one ends (sometimes both ends). I cut the brick in half, and placed the cut side inward. The underside of the arch and front surface are nice. The tip is not finished as nicely (backside of brick), but that won't show.

    In reality, the underside is not seen that much. Turns out to be good, too, because after all the effort, I was not careful with the mortar. I waited too long to pull the arch form, and I have a sloppy mess on the underside of the arch that I can't scrape off.

    I didn't put them on the floor of the arch yet. For reasons you've mentioned, I wasn't sure how it would hold up to the sliding of pans. I've yet to figure out my landing.

    Good luck.
    Mike - Saginaw, MI

    Picasa Web Album
    My oven build thread

    Comment


    • #3
      Re: Bricks for outer arch

      Thanks Mike, good to know. I was hoping to leave the arch bricks a bit longer than yours (looks like you have the short end showing?), which means cutting them. But you're right, only my kids and dog will see the underside of the arch, and all they're concerned with is the next pizzza!
      Picasa web album
      Oven-building thread

      Comment


      • #4
        Re: Bricks for outer arch

        Daren,
        I was looking for something that would kind of match the firebricks ( because I really liked the way they looked) and I found a place that had what they called 'Beige Solids'. An 4x8x2.25" solid brick with at least two 'good sides'.

        I was lucky enough to find 300 of them all matching for $.25/brick!! They have worked SO good. They split really nicely and they are very solid. I would call around and try to find a place that sells 'seconds' who might have something similar.

        Lars.

        ( adding most recent pic so you can see them)
        This may not be my last wood oven...

        Comment


        • #5
          Re: Bricks for outer arch

          I found a place here in Australia that sells dry pressed solids in most natural colours you can get normal bricks and pavers in. The colour is in the clay and doesn't scratch off - colour is the same almost to the centre of the brick.

          I am using some clay pavers for the landing (width of 1/2 a normal brick) and half bricks for the outer arch. All in a dark chocolate which I thought would be a nice contrast to the light cream of firebricks.

          I assume that if i can get them in OZ they make them in other places around the world. Only trouble I found was having to wait for ages to get them because I was only ordering 50 bricks and about 2m squared of pavers when these places deal in pallets of stuff so they have to wait till they are ordering other stuff from the suppliers.

          Cheers
          James
          Real men cook with fire
          My Oven and Fireplace Build

          Comment

          Working...
          X